| File Note: |
It is submitted that the brick kiln was granted consent to operate under the Air (Prevention & Control of Pollution) Act, 1981 vide no. CTOA/Renewal/PTA/2020/12682814 dated 11/06/2020, valid upto 30/09/2028 for manufacturing of Bricks @ 30000 Nos./day (Induced / High Draft Zig Zag Technology) subject to the conditions as mentioned therein.
It is pertinent to mention here that a meeting was taken by the Chairman of the Punjab Pollution Control Board on 28.1.2020 at 11:00 am in the Committee Room, Vatavaran Bhawan, Nabha Road, Patiala with the Punjab Brick Kiln Association regarding compliance of Govt. orders dated 28.05.2019, in which, it was decided that
(1) The Regional Offices of the Board are required to impose / charge environmental compensation from the brick kiln owners from 01.02.2019 to 30.09.2019 for the period for which the brick kilns are actually operated (without converting to the induced draught technology).
(2) In case brick kiln is not operated after 30.06.2019 due to rainy season but the same brick kiln restarted its operations later on but without converting to induced draft technology, then environmental compensation will be levied for full period till the adoption of new technology.
(3) In case, any brick kiln is still operating without adopting the induced draught technology, immediate action for closure of kiln / cancellation of license by DFSC shall be taken.
(4) Following document shall be obtained from the BKOs to ascertain the actual period of operation of the kiln:
a) The Coal Register duly signed by the BKOs and getting an undertaking to the effect that the entries made in the Coal Register are true & correct, may be taken as documentary evidence. e) For the Brick Kiln, which are using other authorized fuel than coal such as agro fuels/biomass, may be asked to submit a self undertaking mentioning the period for which the BKOs had operated the Brick Kiln without conversion into Induced Draught Technology.
b) The documents as mentioned in Para a & b above are to be authenticated by the Charted Accountant.
(5) Since the Brick kilns are generating and discharging very nominal quantity of domestic effluent and are of small scale, as such, the request of the association for exemption of fee for consent under the Water (Prevention & Control of Pollution) Act, 1974 be accepted and may be made applicable w.e.f 1.11.2018 subject to the ex-post facto approval of the Board.
As per the record file, the industry has already obtained varied consents under the Air (Prevention & Control of Pollution) Act, 1981 after converting to induced draft technology and after depositing of EC amounting Rs. 75,000/- vide R. no. 67/5210 dated 03/06/2020 for operating the brick kiln in the month of March, April and May, 2019 and has submitted copy of coal purchase register as documentary proof in this regard (completion certificate issued to it by CSIR-CBRI, Roorkee dated 02/03/2020).
As per the decision no. 5, the brick kiln has now applied for obtaining fresh consent to operate under the Water (Prevention & Control of Pollution) Act, 1974 for manufacturing of Bricks @ 30000 Nos./day (Induced / High Draft ZigZag Technology) for discharge of domestic effluent @ 0.01 KLD, onto land for plantation after passing through septic tank. The brick kiln has submitted compliance report of the conditions of the consent earlier granted to it under the Air (Prevention & Control of Pollution) Act, 1981, latest CA certificate etc.
The industry has deposited following consent fees under the Air (Prevention & Control of Pollution) Act, 1981 against the fixed assets of Rs. 9.13 lakh as per CA certificate dated 31.03.2024.
Water Consent Fee Rs. 5400/- as water consent fee and Rs. 6600/- as water consent fee vide online no. 839682056 dated 02.05.2024 and vide online no. 796673816 dated 07.05.2024 Adequate upto 30/09/2024
NOC regularization fee Rs. 700/- vide online no. 839682056 dated 02.05.2024 Adequate
Accordingly, the industry was visited by the officers of this office on 07.05.2024 and it was observed as under:
• The industry is a brick kiln unit and was found in operation.
• Crushed coal is used as fuel.
• The Brick kiln has already adopted high draft technology for the manufacturing of bricks.
• The brick kiln has provided pucca keri road for the movement of the vehicles.
• The brick kiln has done new plantation along the boundary of brick kiln.
• The brick kiln has covered movement area covered with kairy.
• The brick kiln has provided sampling arrangements with the stack of brick kiln.
• The brick kiln has provided septic tank for treatment of domestic effluent.
Therefore, the industry is now found complying with the provisions of the Water (Prevention & Control of Pollution) Act, 1974 and Air Act, 1981.
In view of above, may, if approved, fresh consent to operate under the Water (Prevention & Control of Pollution) Act, 1974may be granted to the industry upto 30/09/2024 for manufacturing of for manufacturing of Bricks @ 30,000 Nos./day (Induced / High Draft ZigZag Technology) with suitable conditions as per policy of the Board and special condition that:-
I. The industry shall get its stack emission sampling done from Board’s lab immediately.
II. The industry shall comply with the Code of Practice framed for Brick Kilns. The Brick Kiln will ensure the implementation of recommended operating practices as per the feasibility report.
III. The industry will obtain the Environmental Clearance under EIA notification dated 14.09.2006 for mining of brick clay to be used as raw material for the manufacture of bricks.
IV. The industry shall comply with the provisions of notification no. S.O. 763(E) dated 14.9.1999 as amended vide notification no. S.O.979 (E) dated 27.8.2003 and its subsequent amendments issued by the Ministry of Environment & Forests, Government of India, New Delhi.
V. The industry shall adopt the code of practice prescribed by CPCB vide its letter no. 15770 dated 29.01.2019 as under;
i. All the moving area around the main Brick Kiln should be paved with the bricks to minimize the fugitive dust emissions from the Brick Kiln operations.
ii. No dust to accumulate all around the Brick kiln.
VI. The industry shall comply with the code of practice laid down for brick kilns vide Board's notification no. Admn/A-2/F.No. 178/98/3 dated 02.09.1998 and amended from time to time:
i. Approach road within the premises of brick kiln area should be Pucca / stabilized with brick bats.
ii. They should use crushed coal for better burning efficiency.
iii. Height of chimney stack should be at least 30 Mtrs.
VII. The industry shall comply with the recommendations of technology provider as approved by the Board for operating practices to minimize the pollution at source level.
VIII. The industry shall stack its raw brick for baking in zig-zag pattern as recommended by the technology provider as approved by the Board.
IX. The industry shall clean the air pollution control system at regular intervals.
X. The industry shall get its Firemen and Mistries trained from technology provider as approved by the Board for better feeding and firing so as to reduce the pollution.
XI. The industry shall get its emissions analyzed from laboratory approved by the Board / Board’s approved lab/NABL approved laboratory twice in a year/kiln season and shall submit the analysis report to the Board.
XII. The industry shall put up display board indicating environment data at the main entrance gate.
XIII. The BKO shall also obtain NOC/permission from the other Govt. Department, if need be.
XIV. The BKO shall comply with the directions as amended vide Board Office Order no. SEE(HQ2)/2018/606 dated 18.12.2018 as under;
i. The consent is subject to the orders passed by Hon’ble Punjab & Haryana High Court / National Green Tribunal or other Judicial Authority in the case pending or being filed with regard to the subject matter of the office order.
ii. The consent is subject to the performance evaluation of new technology adopted by the brick kilns.
XV. The industry shall inform the Board in writing as and when any change is occurred in the Partnership Deed / Proprietorship / Memorandum of Article of Association, especially with regard to the name and address of the Partner / Proprietor / Director / Subscriber etc, and in any case the industry fails to do so and later on it comes to the notice of the Board that there is any change in Partnership Deed / Proprietorship / Memorandum of Article of Association, action as deem fit under the provision of said Act shall be taken.
XVI. The consent is granted subject to the orders of the Hon'ble Punjab and Haryana High Court in CWP no. 24772 of 2023 titled as Punjab Brick Kiln Owner Association and another Vs State of Punjab from time to time.
(competency- EE, RO, Patiala) |
