| File Note: |
The note of Regional Office may kindly be perused……………………………
The industry is a small scale red category dyeing unit and was granted consent to operate under Water Act, 1974 vide no. CTOW/Renewal/LDH3/2023/21779318 dated 27.12.2023 and Air Act, 1981 vide no. CTOA/Renewal/LDH3/2023/21681887 dated 27.12.2023 for the production of Polyester @ 3750 Kgs/day and Cotton/Cotton Blended Fabrics @ 9 Metric tons/day with the disposal of trade effluent @ 650.0 KLD and domestic effluent @ 4.0 KLD into CETP, which are adequate upto 26.12.2024 and 31.03.2025, respectively…………………………………………….
Thereafter, the industry was granted NOC for expansion under the provisions of the Water (Prevention & Control of Pollution) Act, 1974 and Air (Prevention & Control of Pollution) Act, 1981 vide no. CTE/Exp/LDH3/2024/25361097 dated 30.05.2024 for production of Polyester @ 4900 kgs/day and cotton/cotton blended fabric @ 11700 kgs/day with discharge of trade effluent @ 846 KLD and domestic effluent @ 4.0 KLD into CETP-15 MLD, which is adequate upto 29.05.2025…………………………………….
Now, the industry M/s Sadan Hosiery has applied for new consent to operate under Air (Prevention & Control of Pollution) Act, 1981 for the production of Polyester @ 4900 kgs/day and cotton/cotton blended fabric @ 11700 kgs/day with discharge of trade effluent @ 846 KLD and domestic effluent @ 4.0 KLD into CETP-15 MLD…………………………………………..
The industry has deposited consent fee, which is adequate upto 31.03.2030 as verified by the Regional Office…………………………………………...
The industry has submitted copy of CLU from ATP, Municipal Corporation, Ludhiana vide no. 21/ATP/A/D dated 15.04.2024 mentioning that the site of the industry falls in Industrial Zone as per Master Plan Ludhiana…………………………………………...
The industry was visited by officer of the Board on 25.07.2024 and observed as under:
1. The industry was in operation and engaged in the process of dyeing of fabrics.
2. The industry has installed one boiler of capacity 05 TPH and one thermopak of capacity 200000 Kcal/hour with common stack of adequate height inside the premises, separate cyclones followed by wet scrubbers were installed with boiler and thermopak. The industry is using pet coke as fuel for boiler as well as thermopak and it is complying with the code of practice framed for using pet coke as fuel. During visit stack of the industry was almost clear as it was not emitting black/ dense smoke from its stack.
3. Earlier, air emission sampling of the industry was carried out on 21.11.2023 and as per the analysis report received from the zonal lab, concentration of SPM & SO2 were found 280 mg/Nm3 against the limit of 500 mg/ Nm3 and 275 mg/Nm3 against the limit of 400 mg/Nm3, hence same were found within the limits prescribed by the Board.
4. The industry has installed 01 DG set of capacity 400 KVA fitted with canopy.
5. The industry is complying with the provisions of Air (Prevention & Control of Pollution) Act, 1981……………………………...
As proposed by Regional Office, may if approved, fresh consent to operate under Air (Prevention & Control of Pollution) Act, 1981 be granted to the industry for the production of Polyester @ 4900 kgs/day and cotton/cotton blended fabric @ 11700 kgs/day with discharge of trade effluent @ 846 KLD and domestic effluent @ 4.0 KLD into CETP-15 MLD upto 30.06.2029 with usual terms & conditions, please…………………………….
Competency: Worthy Chairman of the Board (Project Cost: 27.92 Cr) |
