| File Note: |
It is submitted that the industry is a large-scale red category unit and engaged in the business of manufacturing of Cotton Yarn @ 140 TPD, Cotton Acrylic @ 14.75 TPD, Polyster Viscos @ 6.8 TPD & Open end @ 47.40 TPD by using Natural Cotton Fiber @ 209.39 TPD & Man made Acrylic Fiber @ 5.16 TPD as raw material.
1. The industry has been granted 'Consents to Operate' under the Water (Prevention & Control of Pollution) Act, 1974 & the Air (Prevention & Control of Pollution) Act, 1981, vide certificate no. CTOW/Renewal/BAR/2021/15598521 and CTOA/Renewal/BAR/2021/14891900 respectively which are valid upto 31.03.2026.
2. Now, the industry has applied for renewal of 'Consents to Operate' under the Water (Prevention & Control of Pollution) Act, 1974 & the Air (Prevention & Control of Pollution) Act, 1981, vide application no. 31043133 and 31043126 on 19.02.2026 for manufacturing of Cotton yarn @ 140 TPD, Cotton Acrylic @ 14.75 TPD, Polyster Viscos @ 6.8 TPD and Open end @ 47.40 TPD by using raw materials Natural Cotton @ 209.39 MTD and Man-Made Acrylic @ 5.16 MTD.
3. The industry has submitted CTO fees under the Water Act, 1974 of Rs. 28,20,000/- vide receipt no. ICICR52026021800299890 dated 18.02.2026 & Air Act, 1981 of Rs. 28,20,000/- vide receipt no. ICICR52026021800300268 dated 18.02.2026 which is adequate for five years upto 31.03.2031 (as per annum fees= 5,64,000 /- for Red category between 500 cr. to 1000 cr.). The gross fixed assets of the industry have been increased from Rs. 745.6704 crores to Rs. 937.19 crores during the period 31/03/2021 to 30/09/2025 for which industry has deposited NOC Regularization fees of Rs. 2,16,000/- vide receipt no. ICICR52026022700862996 dated 27.02.2026.
4. The industry has submitted CA Certificate of fixed asset value of 93,719 lakhs; Compliance report of earlier granted CTO in annotated form; analysis report of effluent emission of its unit, plantation area plan, the industry has submitted an undertaking dated 27.02.2026 stating purchase of freehold land adjoining the boundary wall, which is presently being used only for agriculture/plantation purposes
The industry was visited by EE and undersigned AEE of this office on 06.03.2026 and it was observed as under:
1. The industry was in operation during the visit and engaged in manufacturing of Cotton yarn, Cotton Acrylic, Polyester Viscos & Open end from natural cotton fiber and manmade Acrylic fiber with the help of five spinning units.
2. The manufacturing process of the industry is as under:- Raw Material→Sorting → Blow room → Carding → Breaker draw frame → Finisher Draw frame → Open end yarn→ Conditioning & packing → FG Godown → Dispatch
3. The industry has provided rotary filters as APCD for control of process emissions. During visit, the APCD was in operation.
4. The industry has no source of air pollution like boiler, furnace etc.
5. The industry has two D.G sets of capacity 1000 KVA and one D.G set of capacity 500 KVA, each with canopy and adequate stack height.
6. The industry has no source of trade effluent generation.
7. The industry has installed two no. STPs of capacity ( STP-I 240 KLD & STP -II 150 KLD) for the treatment of domestic effluent qty 390 KLD and the treated effluent is discharged onto land for plantation in an area of 6 Acres.
8. During visit, both STPs were in operation and the industry is maintaining the record of operation of both STPs. The treated domestic effluent was being discharged onto land for plantation.
Earlier, the industry was visited by EE and undersigned AEE of this office on 19.12.2025 and Effluent samples were collected from the inlet and outlet of both STP of capacity 240KLD & 150 KLD of Trident yarn division and sent to Water lab, Patiala for analysis. As per Effluent sample report, the parameters are as follows: - pH value at 25°C = (Inlet of STP-1 = 7.9 & Outlet of STP-1 = 8.0); (Inlet of STP-2 = 7.9 & Outlet of STP-2 = 8.1); Total Suspended Solids (TSS in mg/l)= (Inlet of STP-1 = 232 & Outlet of STP-1 = 13); (Inlet of STP-2 = 10 & Outlet of STP-2 = 8); Total Dissolved Solids (TDS in mg/l) = (Inlet of STP-1 = 1240 & Outlet of STP-1 = 1206); (Inlet of STP-2 = 1154 & Outlet of STP-2 = 1216); Chemical Oxygen Demand (COD in mg/l) = (Inlet of STP-1 = 342 & Outlet of STP-1 = 67); (Inlet of STP-2 = 60 & Outlet of STP-2 = 30); Bio-Chemical Oxygen Demand (BOD in mg/l) = (Inlet of STP-1 = 125 & Outlet of STP-1 = 14); (Inlet of STP-2 = 12 & Outlet of STP-2 = 10) and Oil & Grease (in mg/l) = (Inlet of STP-1 = 12 & Outlet of STP-1 = BDL); (Inlet of STP-2 = 5 & Outlet of STP-2 = BDL) As per the report, all these parameters were within prescribed limits of the Board. (copy attached)
From the above, it is evident that the industry is complying with the provisions of Water Act, 1974 and Air Act, 1981.
Keeping in view of above, may if approved, it is recommended that renewal of consent to operate under Water Act, 1974 & the Air Act, 1981, may please be granted to the industry for the manufacturing of Cotton yarn @ 140 TPD, Cotton Acrylic @ 14.75 TPD, Polyster Viscos @ 6.8 TPD and Open end @ 47.40 TPD by using raw materials Natural Cotton @ 209.39 MTD and Man-Made Acrylic @ 5.16 MTD for the period of five years valid up to 31/03/2031 with subject to suitable conditions mentioned alongwith following specific conditions: -
1. The industry shall operate the STPs regularly & efficiently, so as to achieve the prescribed effluent standards on regular basis.
2. The industry shall utilize its treated effluent onto land for plantation purposes in scientific manner, so as to avoid any stagnation.
3. The industry shall not add any additional air pollution process without obtaining prior written permission of the Board.
4. The industry shall not increase its production capacity without obtaining prior written permission of the Board.
5. The industry shall not dispose off its treated/ untreated effluent in an unauthorized manner.
6. The industry shall utilize its treated effluent onto land for plantation purposes in scientific manner, so as to avoid any stagnation.
7. The industry shall plant trees wherever space is available inside and outside the unit.
8. The industry shall not undertake expansion without obtaining approval from the Board.
9. The industry shall develop the vermin composting/composting to manage the biodegradable solid waste. The industry shall not throw, burn or bury any solid wastes in open, outside premises or in drain / water bodies.
10. The industry shall promote use of alternatives of single use plastics (SUP) and awareness to discourage use of plastic, through their Corporate Environment Responsibility (CER) activities.
11. The industry shall ensure that there are no usages of single use plastic- thermocol disposable items such as water bottles / water pouches/water cups, plates, forks, spoons, straw etc. and single use decorating material made of plastic-thermocol or any other non-biodegradable material in the premises.
12. The industry shall comply with all the instructions / directions issued or to be issued in future by PPCB/ CPCB for the betterment of environment in the area.
Large Scale; Red Category Industry; Project Cost: 937.19 Crores
Competency: Worthy Chairperson of the Board
|
