| File Note: |
The industry is large scale drug manufacturing unit and was granted consent to operate under Water (Prevention & Control of Pollution) Act, 1974 valid upto 19.03.2017 & under Air (Prevention & Control of Pollution) Act, 1981 upto 31.03.2019. • Now, the industry has applied for renewal of consent to operate under Water (Prevention & Control of Pollution) Act, 1974 for production capacity i.e for production capacity for total production capacity of Amoxicillin by enzymatic route @ 4700 MT/year, Ampicilin Tryhydrates (all grades) @ 750MT/year, Cloxacillins, Dicloxacillin, Oxacillin, Flucloxacillin and Cloxacillin (all grades) @ 1050 MT/year, Atorvastatin @ 135 MT/year, Rosuvastatain @ 50 MT/year, Premixes all graded @ 200 MT/year and Ethyl Hexanoic acid @ 750 MT/year and Bio Gas 2 M3/hr. • The industry has installed ETP for the treatment of trade effluent as well as domestic effluent generated from the industry. It is intimated that the effluent sampling of the subject cited industry was carried out by the PBTI Lab on 12.03.2018 and the results were found within the prescribed limits of the Board. Further, the industry was earlier visited on 28.03.2018 and the stack emission sampling of the incinerator was carried out and as per analysis results, the concentration of various parameters was found within the limits. • The industry was visited by AEE of this office on 31.07.2018 and during visit, it was observed as under:- 1. The industry was in operation and ETP was also in operation. The ETP consisting of 1) High TDS Stream – Collection Tank, MEE, ATFD 2) Low TDS Stream – selector, primary aeration tank, primary clarifier 02 Nos., secondary aeration tank, secondary clarifier, sand filter, carbon filter followed by RO system, RO permeate discharged onto land for plantation and RO reject is sent to MEE. The industry has planted trees and total area is 02 Acres for utilization of the treated effluent. However, the treated effluent is used into the process. 2. The industry has installed online monitoring system at the outlet of ETP 3. The industry reuse treated effluent in cooling towers and process. 4. The industry has provided 11 location for air sparging and 3 location for in situ chemical oxidation to remove contamination of ground water and same were being operated. 5. The pilot project for the production of Pitvastatin @ 1 MTA and Caspofungin @ 0.1 MTA has been installed by the industry and all the construction work / machinery installation work has been completed.
In view of above, if approved consent to operate underAir (Prevention & Control of Pollution) Act, 1981 may be granted to the industry for the period upto 31.03.2019.(competancy chairman of the Board) |
